Procedures - SB-11-6410003

NOMENCLATURE

NSN

TYPE NO

from defects in materiel, workmanship, and design and

will operate in its intended environment in accordance

C-10048/ARN.

Control, Re-

5826-01-020-

with the specifications of the contract for a period of 6

123(V)

ceiver

2263

years. THE EQUIPMENT WILL CONTAIN AP-

R-2023/ARN-

Receiver, Radio

5826-01-020-

PROPRIATE SEALS WHICH MUST NOT BE

123(V)

2258

BROKEN OR TAMPERED WITH IN ORDER TO

R-2139/ARN-

Receiver, Radio

5826-01 -070-

COMPLY WITH WARRANTY CONDITIONS OF

123(V)

4065

THE CONTRACT. It should be noted that all items

MT-4834/ARN-

Mounting Base,

5826-01-020

returned for repair to the contractor will undergo a joint

123(V)

2266

Electrical

inspection at the contractor's plant by both a govern-

Equipment

ment and a contractor representative. If this inspection

MT-4980/ARN-

Mounting Base,

5826-01-058-

discloses broken seals or the radio receiver, control, or

123(V)

7717

Electrical

mounting have been tampered with, or undergone

Equipment

willful mistreatment, such units will not be repaired

R-1963/ARN

Receiver, Radio

5826-01-015-

under the contract warranty. These units will be

1574

repaired under a separate maintenance contract with the

Mounting Base,

MT-4835/ARN

5826-01 -022-

manufacturer.

Electrical

9257

b. Under the contract terms of the warranty, the con-

Equipment

tractors shall not be obligated for the repair of any radio

b. Materiel Flow:

receivers under this warranty if failure of nonconfor-

(1) A general repair and return warranty flow

mance is caused by fire, explosion, submersion, aircraft

diagram for AN/ARN-123(V)( ), Receiving Set, Radio,

crash, enemy action, natural disaster, and/or accidental

and R-1963/ARN, Receiver, Radio, is shown in figure

or willful mistreatment. However, receivers damaged or

requiring repair because of the aforementioned causes,

(2) As indicated in paragraph a above, those com-

are still required to be returned to the contractor for

ponents requiring repair will be returned directly to the

final inspection, evaluation and disposition. It should

contractor, addressed and marked as follows:

be noted that items returned in the above categories

Bendix Corporation

which are found to void the warranty will still be

Avionics Division

evaluated for repair under a separate contract with the

2100 N.W. 62nd Street

manufacturer.

Ft. Lauderdale, Florida 33310

c. Warranty and contract terms contain monetary

ATTN: CONUS Repair Service Administrator

penalty conditions to the government involving the

Reliability Improvement Warranty

return of radio receivers found to be operating satisfac-

M/F:

torily by the contractor and Government Product

Contract DAAB07-75-C-0853

Assurance personnel upon inspection at the plant.

NOTE

Evacuating activities of radio receivers should therefore

Using activities should not requisition

follow the applicable procedures involving the tests

replacements for those components returned

prescribed in TM's at the respective support levels to

for Repair and Return under this equipment

assure that a receiver is not functioning as required

warranty program.

before returning equipment for repair. Penalty charges

c. AVUM Procedures. Using technical manual pro-

of $100.00 per radio set will be charged to the govern-

cedures, AVUM will verify that a Line Replaceable Unit

ment when no verified failure of the equipment occurs.

(LRU) has failed. The LRU will be removed from the

Based on this fact, using units must ensure that, prior to

aircraft; DA Form 2407 prepared, logbook entries

return of equipment for warranty, all prescribed tests

made, and the Installation/Removal Data Label affixed

performed verify that an unserviceable unit exists.

to the LRU will be filled out. The LRU will be taken to

AVIM and exchanged for a good LRU. AVUM will

5. Scope: These instructions provide Army field com-

then fill in the information on the Installation/Removal

manders, other services and authorized contract

Data Label on the replacement unit, install the LRU in

facilities (including airframe manufacturers and com-

the aircraft; and make the appropriate entries in the air-

mercial airframe overhaul facilities) involved with Army

craft logbook.

aircraft, with the method of disposition, handling and

d. A VIM Procedures. AVIM will verify that the

accounting, under the Reliability Improvement Warran-

LRU brought by AVUM has failed using TM pro-

ty (RIW).

cedures. AVIM will then give AVUM a good LRU from

6. Procedures: a. Equipment under Warranty: Items

stock and package the failed LRU in the same packag-

authorized for Repair and Return under Contract

ing that has been used to store the spare LRU. AVIM

DAAB07-75-C-0853 are identified as follows:

will prepare a DD Form 1348-1 with MILSTRIP docu-